PUMPER APPARATUS SCHEDULE "B" SERVICE

TASK DESCRIPTION

* WALK AROUND/EXTERIOR INSPECTION*

CAB & BODY EXTERIOR INSPECT OVERALL CONDITION CHECK FLUID LEAKS CHECK AIR LEAKS TIRES/CHECK PRESSURE/WEAR/DAMAGE MUD FLAPS/INSPECT MISSING CAPS, OIL, FUEL/INSPECT LIGHTS OEM/CHECK OPERATION LIGHTS/PURSUIT/CODE 3/CHECK OPERATION LIGHTS/EMERGENCY/SAFETY/CHECK OPERATION LIGHTS/ALLEY/WORK CHECK OPERATION

* HARDWARE CHECK *

CAB INSIDE
CAB OUTSIDE
BODY, LEFT SIDE
BODY, RIGHT SIDE
BODY, TOP
BODY, REAR

* SAFETY EQUIPMENT INSPECTION *

WHEEL CHOCKS/INSPECT
SIGNAGE/INSPECT

* IN CAB/TEST DRIVE INSPECTION *

DOOR LATCHES/HINGES/LOCKS/INSPECT
CAB INTERIOR/INSPECT OVERALL CONDITION
MIRRORS/CHECK OPERATION
WINDSHIELD/WASHER/WIPER/CHECK OPERATION
COMMUNICATION EQUIPMENT/CHECK OPERATION
HORNS/SIRENS/ALARMS/CHECK OPERATION
BRAKES/A.B.S./SYSTEM CHECK
SEAT BELTS/RESTRAINTS/HARNESS/CHECK
STARTER/CRANKING SYSTEM CHECK OPERATION
INSTRUMENT PANEL/GAUGES/LIGHTS/BUZZERS/SIGNAL
THROTTLE/CHECK OPERATION
BRAKES/5 POINT INSPECTION
P.T.O./CHECK OPERATION
TRANS SHIFT CONTROLS/CHECK OPERATION
ROAD TEST/TEST DRIVE
A/C & HEATING/CHECK OPERATION
ENGINE/JACOBS BRAKE/CHECK OPERATION
RETARDER/ELECTRIC/CHECK OPERATION
TRANS OUTPUT RETARDER/CHECK OPERATION
BRAKE PARKING/CHECK OPERATION
LIGHTS/HEADLIGHTS CHECK/ADJUST

*PRIMARY ENGINE *

CAB JACK/CHECK FLUID LEVEL/OPERATION
PRESSURE CLEAN ENGINE
ENGINE OIL/CHECK/ADD
CRANK CASE BREATHER TUBES/INSPECT
THROTTLE LINKAGE/CHECK OPERATION/LUBE
ENGINE THROTTLE/CHECK FULL FUEL POSITIONING
ENGINE/CHECK/ADJUST SHUT DOWN MECHANISM
ENGINE/ADJUST THROTTLE DELAY/FUEL MODULATOR
COMPRESSOR FILTER/CHECK/CHANGE
WASHER WINDSHIELD/CHECK/FILL/RESERVOIR
TURBO CHARGER CONNECT/INSPECT
AIR BRAKES/COMPRESSOR/CHECK
ENGINE/DRIVE BELTS/CHECK WEAR/ADJUST
STEERING GEAR BOX/CHECK FLUID LEVEL
POWER STEERING PUMP/CHECK FLUID
FUEL SYSTEM/CHECK TANK CONTAMINATION
FUEL FILTER/REPLACE
WATER FILTER/SEPARATOR/REPLACE
BATTERY CABLES/CHECK/CLEAN
BATTERY/TEST AND SERVICE
CHARGING SYSTEM/CHECK
VOLTLAGE REGULATOR/CHECK
ALTERNATOR/CHECK OUTPUT
COOLING SYSTEM WATER PUMP/CHECK
COOLING SYSTEM FAN/CLUTCH/CHECK
RADIATOR/MOUNTS/INSPECT
COOLING SYSTEM HOSES/CHECK/REPLACE
RADIATOR/CAP/CHECK
COOLING SYSTEM/PRESSURE CHECK
COOLING SYSTEM/LITMUS TEST
COOLANT DRAIN/REPLACE
COOLING SYSTEM/FILTER REPLACE
COOLANT CHECK/ADD
TRANS FLUID/CHECK LEVEL
ENGINE COVER BOLTS/CHECK/TIGHTEN

* UNDER VEHICLE *

ENGINE/CHANGE OIL/FILTER
COOLING SYSTEM/FREEZE PLUGS/CHECK
KING PINS/BALL JOINTS/CHECK FOR WEAR
LUBRICATE KING PINS/BALL JOINTS
TIE ROD/DRAG LINK/PITMAN ARM/CHECK PLAY
LUBRICATE TIE ROD/DRAG LINK/PITMAN ARM
STEERING GEAR/LINKAGE/CHECK FOR PLAY
SUSPENSION/CHECK PINS/BUSHINGS
RETARDER/ELECTRIC/LUBE
U-JOINT/FLANGES/CHECK
LUBE U-JOINT/FLANGES/CHECK
PUMP (FIRE) TRANS/LUBE OUTBOARD/3RD STAGE BRG
SUSPENSION/CHECK SPRINGS/SHACKLES/SHOCKS
POWER STEERING/INSPECT LINES/HOSES/FITTINGS
SUSPENSION/CHECK TORQUE ON U-BOLTS
EXHAUST SYSTEM/INSPECT
AIR BOX DRAIN/INSPECT
ENGINE OIL COOLER LINES/INSPECT FOR LEAKS
FUEL PUMP/INSPECT
FUEL SYSTEM/CHECK LINES/MOUNTING
ENGINE MOUNTS/INSPECT
PUMP (FIRE) TRANS/CHECK/DRIVELINE/U-JOINTS
LUBE PUMP/TRANS/U-JOINTS
DIFFERENTIAL/CHECK FLUID LEVEL/CLEAN VENTS
CAB & BODY/MOUNTS/CRACKS/HARDWARE/INSPECT
AIR SYSTEM/CHECK LINES/HOSES/FITTINGS
FUEL SYSTEM TANK DRAIN/CHECK
FRAME AND SUPPORTS CHECK FOR CRACKS
TRANS/CHECK MOUNTS/LINES/FITTINGS
TRANS/CHECK LINKAGE
PUMP (FIRE) TRANS/CHECK FLUID LEVEL/LEAKS
GEAR BOXES/CHECK FLUID LEVEL
BRAKES/AIR TANK/DRAIN
HUBS/CHECK OIL LEVEL
STUDS/THREADS/LUG NUTS/CHECK
WHEELS/INSPECT FOR CRACKS
BRAKES/INSPECT SHOES/PADS/WEAR
BRAKES/INSPECT LINES/HOSES/WHEEL CYLINDERS
WHEEL BEARINGS/SEALS/REPACK/REPLACE
BRAKES/CHECK/ SLACK ADJUSTERS
BRAKES/AIR DRYER/SERVICE
ADJUST BRAKES

* Pump Service *

PUMP (FIRE) PRIMING TANK/CHECK LEVEL
PUMP PRIMER MOTOR/CHECK
PUMP (FIRE) DRY VACUUM TEST/PRESSURE TEST
PUMP VALVES/SUCTION/DISCHARGE/CHECK
PUMP (FIRE) SHIFT UNIT/CHECK
PUMP (FIRE) PANEL THROTTLE/CHECK OPERATION
PUMP (FIRE) CHECK PACKING FOR LEAKAGE/ADJUST
PUMP (FIRE) CHECK DISCHARGE DRAINS
PUMP (FIRE) CHECK PUMP OPERATION
PUMP (FIRE) TRANSFER VALVE/CHECK/POSITIONS/LUBE
PUMP (FIRE) PRESSURE GOVERNOR/CHECK OPERATION
PUMP (FIRE) PRESS RELIEF VALVE/CHECK OPERATION
PUMP (FIRE) FOAM/CHECK OPERATION/MIXING PERCENT
PUMP PRIMING (FIRE) PILOT VALVE/CLEAN SCREEN
PUMP (FIRE) CHANGE OIL


© Fire Apparatus Repair Inc. 2013
Site Designed and Maintained by: Cerberus Technology Solutions